The Step-by-Step Guide to Repairing Water Leaks of Air Cooler

 

Air coolers are a great method of overcoming the hot weather and relief on hot summer afternoons. But as with all other appliances, air coolers also go wrong after some time. One such issue with which the consumers are beset is water leakage. If you have observed water oozing out of your air cooler, panic not. In this article, we are going to take you through the primary causes of water leakage, how to diagnose the issue, and give you advice on maintaining your cooler in its optimal working state.

1. Understanding Air Cooler Water Leakage

Swamp coolers or air coolers lower air temperature through evaporation of water. Water is stored in a reservoir and pumped through pads on which water-charged air is blown as driven by a fan. When it comes to summer , air coolers are best to use and also they are eco-friendly , but the water leakage is the common problem happen in cooler . to know the right reason of leakage is important to understand why the leakage is occurring . 

2. Air Cooler Water Leak Causes

2.1. Water Overfill in the Water Tank

Water overfill in the tank above the recommended level is the most frequent reason for water leakage in air coolers. The water level gauge is usually fitted in most air coolers. Water overfill in the tank above the recommended level implies that the excess water will overflow. Most of the time, it is a simple thing to correct—drain water and make sure the fill line on the tank.

2.2.Fouled or Blocked Water Pump

Water pump of the air cooler is used to force water into the cooling pads. Mud, dirt, or water mineral deposit due to use clogs up the pump. It can provide a chance for excessive overflow and dripping of the machine. It is avoided by cleaning and being freed from clogging.

2.3.Broken Water Tank or Water Pipe

Leakage of water can also result from a burst of the water pipe or crack or hole in the water tank. They are caused by physical damage and wear and tear. If you discover water at ground level on the cooler, inspect the water tank and pipes for physical damage. If you discover a crack, you may be required to replace the faulty unit.

2.4. Inadequate Installation of Water Pads

Water pads are an important component of an air cooler that soak up water and allow it to evaporate. Malfunctioning or incorrectly set water pads would not soak up water and would lead to excessive over-overflow of water. Correct water pads correctly, and replace them if they appear to be damaged.

2.5. Defective Float Valve

A faulty float valve will permit extra water to exit the tank and spill. Float valve regulates the amount of water pumped into the tank in an attempt to prevent spilling from the tank. Water will continue to be pumped into the tank if it is clogged or rusted to the extent of creating leaks. This shall be rectified through float valve repair or replacement.

3. Troubleshooting Water Leak in Air Coolers

Now, with all the common water seeped in position, let us proceed with the steps of repair to get rid of the problem:

3.1. Step 1: Inspect the Water Tank

Begin with inspecting the water tank to ensure that no extra filling has been done. The water should not be at or above the top of the maximum fill level. Drainage of some portion of the waters if needed and set the level at the proper mark.

3.2. Step 2: Clean the Water Pump

Pull out the cooler and shove it towards the back. Pull out the water pump and check for trash, dust, or minerals. Drain the pump using a brush or rag. 

3.3. Step 3: diagnose the water pump and motor 

Second, check water tank and water pipes for any cracks, leakages, or damages. When you spot any of them, you can attempt to seal them using waterproof sealant. If damage is major, you may be compelled to replace the damaged parts.

3.4. Step 4: Check Water Pads for proper installation

Make sure the water pads are installed such that they can be placed within their respective compartments. Replace them with new ones upon damage or wear out. Properly fitting water pads will ensure a smooth water distribution, thus preventing spillage.

3.5. Step 5: Test the Float Valve

Float valve is a crucial device in tank water level control. Overfill and leakage will result if the valve is damaged or clogged. Float valve test can be carried out by unbolt the valve and inspect for damages or blockage. Replace the valve in case of defects and this issue will be avoided.

3.6. Step 6: Proper Location

Finally, place the air cooler on a hard, flat surface. Never tilt or place the cooler so that water spills. A hard and flat surface will see the water flowing smoothly without unnecessarily spilling.

4. How to Keep Your Air Cooler Away from Water Spilling

It is easier to avoid water leakage than to correct it. The following are some maintenance tips so that your air cooler works at its best:

4. 1. Regular Cleaning

Clean your air cooler from time to time, especially the pump and water tank, and the cooling pads. This will prevent clogging of the system and leakage by preventing dust and dirt accumulation.

4.2. Wear and Tear Check

Inspect the water tank, pipes, and water pads for wear. Replacing them while they are in their prime will prevent leaks and maintain your air cooler in a good condition.

4.3. Good Quality of Water

Use new, filtered water with your air cooler. Hard water containing high minerals can clog pipes and scale and cause pump as well as water leakage. Drain the water tank occasionally to drain out any mineral deposit.

4.4. Storing Your Air Cooler

Keep your air cold, when you are not going to use it, in a dry, cool place so that no damage is caused to the tank or any other component. Drain the water tank before you store it so that there is no mold buildup.

5. Conclusion

Water leakage in air coolers is a frustrating issue, but by proper knowledge and maintenance, you can easily find and repair it. You simply have to follow the guide steps, and leakage will be avoided, and you can use your air cooler for years without any issue. Maintain the water tank, pump, water pads, and float valve properly from time to time and perform routine maintenance so that your air cooler is in perfect working condition.

Through these simple steps, you are going to receive cool air with the provision of cool fresh air that you need without any leakage problem of water.